Sơ Đồ Mạch Điện Mitsubishi Mirage 2012-2019

tài liệu hướng dẫn sửa chữa mitsubishi Miragehướng dẫn đọc sơ đồ mạch điện mitsubishitra cứu sơ đồ mạch điện mitsubishi Miragecẩm nang sửa chữa mitsubishi Miragewiring diagram misubishi Mirage service manual misubishi mirageworkshop manual misubishi mirage

Trang 1

TAILLIGHT, POSITION LIGHT, 

SIDE MARKER LIGHT, LICENSE 

PLATE LIGHT AND LIGHTING 

MONITOR TONE ALARM 90-76

FOG LIGHT 90-82

COMPARTMENT LIGHT 90-86

TURN-SIGNAL LIGHT AND 

HAZARD WARNING LIGHT 90-92

BACKUP LIGHT 90-97

STOPLIGHT 90-98

HORN 90-99

METER AND GAUGE 90-100

BRAKE WARNING LIGHT, FUEL 

WARNING LIGHT AND OIL 

PRESSURE WARNING LIGHT 90-104

POWER WINDOWS <VEHICLES 

WITHOUT SAFETY SYSTEM> 90-108

POWER WINDOWS <VEHICLES 

WITH SAFETY SYSTEM> 90-112

CENTRAL DOOR LOCKING 

Trang 2

WASHER 90-146

REAR WIPER AND WASHER 90-150

REAR WINDOW DEFOGGER AND 

DOOR MIRROR HEATER 

<VEHICLES WITHOUT 

AUTOMATIC AIR CONDITIONING 

SYSTEM> 90-154

REAR WINDOW DEFOGGER AND 

DOOR MIRROR HEATER 

<VEHICLES WITH AUTOMATIC 

AIR CONDITIONING SYSTEM> 90-158

REMOTE CONTROLLED DOOR 

ANTI-LOCK BRAKING SYSTEM 

(ABS), ACTIVE STABILITY 

CONTROL SYSTEM (ASC) AND 

HILL START ASSIST SYSTEM 

<VEHICLES WITHOUT KOS> 90-198

STEERING LOCK <VEHICLES 

WITHOUT KOS (CVT)> 90-200

ONE TOUCH START SYSTEM 90-202

CRUISE CONTROL SYSTEM 90-212

TIRE PRESSURE MONITORING 

SYSTEM (TPMS) 90-218

PANIC ALARM 90-222

HEATED SEAT 90-228

IGNITION KEY REMINDER TONE 

ALARM <VEHICLES WITHOUT 

Trang 4

HOW TO READ CIRCUIT DIAGRAMS

M1901000100964The circuit of each system from the fuse (or fusible link) to ground is shown The power supply is shown at the top and the ground at the bottom to facilitate understanding of how the current flows Some variations are included in one circuit diagram Accordingly, some diagrams may not be applicable for individual vehicles.The circuit diagrams show the state when switches are operated.

FUSIBLE LINK 1

FUSIBLE LINK 2

ECU MOTOR

ECU

SENSOR

RELAY BOX

RELAY

RESISTOR

SWITCH

DIODE

Indicates power supply Indicates connector number

The same numbers are used in thewiring harness diagram

Connector and connector numbersare shown at the lower part of thepage

Connector numbers not enclosed

by frame indicate the device porated into wiring harness

incor-Indicates shield wire

Indicates the connector symbol

Connectors in the circuit diagram

are indicated in numerical order

Indicates that the diagram

contin-ues at which belongs to the

block in the same circuit

An "X" at the end of a connector

number indicates that the

conn-ector is connected to a

central-ized junction that is shown in the

section "Centralized Junction."

Indicates equipment which the

branched harness wire leads to

Each circuit diagram consists of

block(s)

Indicates that terminal is

conne-cted via a plate in the relay box

Indicates splice point numbers

These numbers are identical to

those described in "Splice

Loca-tions."

Trang 5

MOTOR SENSOR

RESISTOR IGNITION

SWITCH (IG1)

SOLENOID

VALVE 1

SOLENOID VALVE 2

SOLENOID VALVE ASSEMBLY

AB

Example C-15-2 Indicates a connector

which is inside the equipment, numbered

in order starting from 1

Indicates the connector number shown in

the wiring harness configuration diagram

Indicates that the diagram comesfrom which belongs to the block in the same circuit

Indicates terminal number

In case two or more connectorsare connected to the same device, markings indicating the same connector are connector

by a broken line

Indicates harness junction wherewire diameter or color changes

Indicates intersections atwhich the lead wires arenot connected

Indicates intersections atwhich the lead wires areconnected

Indicates that the terminal is aspare one if the device (sensor

in this case) is not provided

Indicates representative vehicle body ground point (Same number as that of ground point in GROUNDING LOCATION)

Trang 6

CONNECTOR/GROUNDING INDICATIONS

FUSIBLELINK 6

ECU

MOTOR ASSEMBLY

SENSORRELAY

IGNITION SWITCH (IG1)

SOLENOID VALVE 1

INSPECTION CONNECTOR

ACA03549AB8

Trang 7

single connector contour line.

Connector

symbol

marking

connector is viewed as shown

At a device connection, the connector symbol on the device side is shown For an

intermediate connector, the male connector symbol is shown For spare connectors and check connectors, no device is connected, and so the harness-side connector symbol

is shown for these connectors However, a data link connector

Trang 8

Connector

connection

marking

and the harness is either by direct insertion in the device (direct connection type) or by connection with a harness connector furnished on the device side (harness connection type) The two types are indicated as illustrated 5

6

Ground

marking

ground, device ground or control unit interior ground These are indicated as illustrated.

Trang 9

WIRE COLOR CODES

Wire colors are identified by the following color codes.

If a cable has two colors, the first of the two color code ters indicates the basic color (color of the cable coating) and the second indicates the marking (tracer) color.

Code Wire color Code Wire color Code Wire color Code Wire color

Trang 10

JUNCTION BLOCK

M1901000202730

NO CONNECTION REAR WINDOW

DEFOGGER RELAY

BLOWER RELAY

HEATED SEAT RELAY

FUEL PUMP RELAY

JUNCTION BLOCK SIDE

NOTE ·CONNECTOR NUMBERS ARE KEYED TO THE CONFIGURATION DIAGRAM (INSTRUMENT PANEL) AND EACH CIRCUIT DIAGRAM.

·HEAVY LINES INDICATE THE PARTS CONNECTED

TO THE PLATE (ONLY ON THIS PAGE TO IMPROVE LEGIBILITY).

NO CONNECTION

Trang 11

252624

C-408C-406

C-402C-420

C-405

C-419

To front wiringharness

Fuel pumprelayC-418

No connection

No

connection

No connection

Trang 12

JOINT CONNECTOR

M1901014206218

HEADLIGHT (LH)

JOINT CONEECTOR (1)

RELAY BOX (FUSE ) F1

NOTE:

IN THE ACTUAL VEHICLES, SOME OF THE JOINT CONNECTOR TERMINALS IN THE SAME BUS

ARE USED, SO IN SOME CASES, THE TERMINAL ARRANGEMENT INDICATED ON THE CIRCUIT

DIAGRAMS DOES NOT AGREE WITH THE ONES IN THE ACTUAL VEHICLES.

AS FOR JOINT CONNECTOR (CAN1, 2), REFER TO CAN CIRCUIT.

IN ADDITION, ON JOINT CONNECTOR (CAN1, 2), THE TERMINAL NUMBERS INDICATED

ON THE CIRCUIT DIAGRAMS SHOULD ALWAYS AGREE WITH THE TERMINAL ARRANGEMENT

IN THE ACTUAL VEHICLES.

Trang 13

JUNCTION BLOCK 16 (FUSE )

WINDSHIELD WIPER

STEERING-ECU

COOLING FAN CONTROL RELAY (HIGH)

PTC HEATER

CONTROL

UNIT

Trang 14

JOINT CONNECTOR (CONTINUED)

RELAY BOX

CRANKSHAFT POSITION SENSOR

ENGINE CONTROL MODULE

CAMSHAFT POSITION SENSOR

·BACKUP LIGHT SWITCH <M/T>

·TRANSMISSION RANGE SWITCH <CVT>

·BACKUP LIGHT SWITCH <M/T>

·TRANSMISSION RANGE SWITCH (R) <CVT>

No.2 IGNITION COIL

No.1 IGNITION COIL

TRANSAXLE CONTROL MODULE

No.3 IGNITION

·RADIO AND

CD PLAYER

·REAR COMBINATION LIGHT (BACKUP)

F17 (FUSE )

21 (FUSE )

OUTPUT SPEED SENSOR

PRIMARY SPEED SENSOR

SECONDARY SPEED SENSOR

Trang 15

MANIFOLD ABSOLUTE PRESSURE SENSOR

ENGINE COOLANT TEMPERATURE SENSOR

Trang 16

RELAY BOX

OIL FEEDER CONTROL VALVE

LINEAR AIR-FUEL RATIO SENSOR HEATED OXYGEN SENSOR (REAR)

ETACS-ECU

REAR DOOR SWITCH (RH)

LIFTGATE LATCH SWITCH ASSEMBLY

REAR DOOR LOCK ACTUATOR (LH)

REAR DOOR LOCK ACTUATOR (RH)

ETACS-ECU (DOOR LOCK RELAY)

ETACS-ECU (DOOR UNLOCK RELAY) FRONT DOOR LOCK ACTUATOR (RH)

REAR DOOR LOCK ACTUATOR (LH)

LIFTGATE LATCH SWITCH ASSEMBLY

REAR DOOR SWITCH (LH)

No.3 INJECTOR

No.1 INJECTOR No.2

INJECTOR EVAPORATIVE

EMISSION PURGE SOLENOID VALVE

F23 (FUSE )

FRONT DOOR LOCK ACTUATOR (LH)

FRONT DOOR LOCK ACTUATOR (RH)

Trang 17

AUTO A/C CONTROLLER ASSEMBLY (A/C-ECU)

·MULTIVISION DISPLAY

·RADIO AND

CD PLAYER

HEATED SEAT SWITCH

HEATER CONTROL PANEL

JOINT

CONNECTOR

(7)

HAZARD WARNING LIGHT SWITCH

ASC OFF SWITCH SELECTOR

LEVER ASSEMBLY

COMBINATION METER (PWM)

DOOR MIRROR

ASSEMBLY (RH)

DOOR MIRROR ASSEMBLY (LH)

Trang 18

COLUMN SWITCH ETACS-ECU

JOINT

CONNECTOR

(10)

REMOTE CONTROL MIRROR SWITCH

KEY REMINDER SWITCH

STEERING LOCK SOLENOID

SELECTOR LEVER ASSEMBLY (P RANGE DETECTION

SWITCH

ASC OFF SWITCH

COLUMN SWITCH

JUNCTION BLOCK 13 (FUSE ) COLUMN SWITCH LUGGAGE

COMPARTMENT LIGHT

AUTO A/C CONTROLLER ASSEMBLY (A/C-ECU)

·RADIO AND

CD PLAYER

KOS AND OSS-ECU

JOINT

CONNECTOR

(9)

Trang 19

LISENCE PLATE LIGHT

REAR COMBINATION LIGHT (TAILLIGHT: LH)

REAR COMBINATION LIGHT (LH)

REAR

COMBINATION

LIGHT (BACKUP: RH)

REAR COMBINATION LIGHT (STOPLIGHT: LH)

REAR COMBINATION LIGHT (STOPLIGHT: RH)

HIGH-MOUNTED STOPLIGHT

JOINT CONNECTOR (13)

·RADIO AND

CD PLAYER

Trang 20

ETACS-ECU (taillight relay circuit), IG1 relay circuit, IG2 relay circuit, ignition switch circuit and starter

power window motor

KOS and OSS-ECU and rear combination light (stoplight)

OSS-ECU

module and hands free module

Trang 21

oxygen sensor (rear), injector, linear air-fuel ratio sensor, mass airflow sensor, oil feeder control valve and throttle actuator control motor relay

No F1 to F8, headlight relay (High) and headlight relay (Low)

No BF1, BF2, F12 to F19, F22, F23 and MFI relay

Trang 22

PASSENGER COMPARTMENT

ACC04609

Relay box

Sub relay box

Fusible link box connected

directly to battery positive terminal

SBF3

F21 F22 F23 F24

F12 F13 F14 F15 F16 F17 F18 F19 BF1 BF2

F3 F4 F10 F11

F1 F2

F6 F7

F5 SBF1 SBF2

AD

No Power supply circuit Name Rated

capacity (A)

Housing color

Load circuit

1 ETACS-ECU (taillight

relay)

plate light, position light (LH) and rear combination light (taillight: LH)

2 Ignition switch

(ACC)*1

Trang 23

marker light (RH), hazard warning light switch, heated seat switch, heater control panel, multivision display, position light (RH), radio/CD player, rear combination light (taillight: RH), selector lever assembly and steering wheel multi-function switch

8 Ignition switch

(ACC)*1

ACC relay*2

9 Ignition switch (IG1)*1

actuator, ETACS-ECU (door lock relay and door unlock relay) and liftgate latch switch assembly

(A/C-ECU), column switch, front dome light, KOS and OSS-ECU, lighting control sensor, luggage compartment light, multivision display and radio/CD player

14 Ignition switch

(ACC)*1

ACC relay*2

rear wiper washer relay), rear wiper motor and washer motor

IG1 relay*2

combination meter, EPS-ECU, ETACS-ECU, selector lever assembly and SRS-ECU

Trang 24

NOTE:

1 *1: Vehicles without KOS

2 *2: Vehicles with KOS

IG2 relay*2

controller assembly (A/C-ECU), blower relay, cooling fan control relay (High), cooling fan control relay (Low), heated seat relay, heater control panel, outside/inside air selection damper control motor and rear window defogger relay

19 Rear window

defogger relay

and heater control panel

20 Ignition switch

(ACC)*1

ACC relay*2

relay, wiper automatic stop relay and wiper speed switching relay), washer motor and windshield wiper motor

IG1 relay*2

sensor, passenger’s air bag off indicator light assembly, primary speed sensor, radio/CD player, rear combination light (backup),

secondary speed sensor, SRS-ECU and transaxle control module

radio/CD player and selector lever assembly

No Power supply circuit Name Rated

capacity (A)

Housing color

Load circuit

Trang 25

CENTRALIZED RELAY

ACB04352 AG

4 10 16

5 11 17

6 12 18

7 13 19

8 14 20 9

15 21

23

22 24

26 25

Connector No Name Connector No Name

relay

Trang 26

A-34X A-33X A-32X A-06X

Trang 28

POWER DISTRIBUTION SYSTEM

M1901000406714

BATTERY

ELECTRIC POWER STEERING-ECU STARTER

RELAY BOX

FUSIBLE LINK BOX CONNECTED DIRECTLY

TO BATTERY POSITIVE TERMINAL

ASC-ECU

GENERATOR

HORN RELAY

FOG LIGHT RELAY

COOLING FAN CONTROL RELAY (HIGH)

COOLING FAN CONTROL RELAY (LOW)

Trang 29

HEADLIGHT RELAY (LOW)

PTC HEATER RELAY 1 PTC

HEATER RELAY 2

SUB RELAY BOX

REFER TO HEADLIGHT CIRCUIT

WIRE COLOR CODE

B : BLACK LG : LIGHT GREEN G : GREEN L : BLUE W : WHITE Y : YELLOW SB : SKY BLUE

BR : BROWN O : ORANGE GR : GRAY R : RED P : PINK V : VIOLET PU : PURPLE SI : SILVER

HEADLIGHT

RELAY (HIGH)

HEADLIGHT

Trang 30

POWER DISTRIBUTION SYSTEM (CONTINUED)

FUSIBLELINK

POWER WINDOW MAIN SWITCH

ETACS-ECU (TURN-SIGNAL LIGHT FIELD EFFECT TRANSISTOR)

·COMBINATION METER

·ENGINE CONTROL MODULE

·HANDS FREE MODULE

POWER WINDOW RELAY

STOPLIGHT SWITCH

A/C COMPRESSOR RELAY

Trang 31

FUEL PUMP RELAY

·EVAPORATIVE EMISSION PURGE SOLENOID

·EVAPORATIVE EMISSION VENTILATION SOLENOID

·HEATED OXYGEN SENSOR (REAR)

·LINEAR AIR-FUEL RATIO SENSOR

·MASS AIRFLOW SENSOR

·No.1 TO No.3 INJECTOR

·OIL FEEDER CONTROL VALVE

·THROTTLE ACTUATOR CONTROL MOTOR RELAY

WIRE COLOR CODE

Trang 32

IGNITION SWITCH

FUSIBLE LINKSBF3

RELAY BOXJUNCTION

BLOCK

Trang 33

IG2 RELAY

ACC RELAY

IG1 RELAY

WIRE COLOR CODE

Trang 34

IGNITION SWITCH (ST)

IG1 RELAY

IG2 RELAY

·ASC-ECU

·COLUMN SWITCH

·COMBINATION METER

·ELECTRIC POWER STEERING-ECU

·ETACS-ECU

·PTC HEATER CONTROL UNIT

·A/C COMPRESSOR RELAY

·AUTO A/C CONTROLLER ASSEMBLY (A/C-ECU)

·BLOWER RELAY

·COOLING FAN CONTROL RELAY (HIGH)

·COOLING FAN CONTROL RELAY (LOW)

·HEATED SEAT RELAY

·HEATER CONTROL PANEL

·OUTSIDE/INSIDE AIR SELECTION DAMPER CONTROL MOTOR

·ENGINE CONTROL MODULE

·FUEL PUMP RELAY

·BACKUP LIGHT SWITCH

·OUTPUT SPEED SENSOR

·PASSENGER'S AIR BAG OFF INDICATOR LIGHT ASSEMBLY

·PRIMARY SPEED SENSOR

·SECONDARY SPEED SENSOR

·SRS-ECU

·TRANSAXLE CONTROL MODULE

·TRANSMISSION RANGE SWITCH

Trang 35

REMOTE CONTROL MIRROR SWITCH

JUNCTIONBLOCK

: VEHICLES WITHOUT KOS 1

: VEHICLES WITH KOS 2

·ETACS-ECU

·REAR WIPER MOTOR

·REAR WIPER RELAY

·REAR WIPER WASHER RELAY

·ETACS-ECU

·WINDSHIELD WIPER MOTOR

·WINDSHIELD WASHER RELAY

·WIPER AUTOMATIC STOP RELAY

·WIPER SPEED SWITCHING RELAY

WIRE COLOR CODE

Trang 36

2

FUSIBLE

LINK

REAR WINDOW DEFOGGER RELAY

JUNCTION BLOCK SIDE

·DATA LINK CONNECTOR

·ETACS-ECU (DOOR LOCK /UNLOCK RELAY)

BLOWER RELAY

REAR WINDOW DEFOGGER

·DOOR MIRROR ASSEMBLY (MIRROR HEATER)

·HEATER CONTROL PANEL ETACS-ECU

FUSE 16

HEATED SEAT RELAY

Trang 37

·AUTO A/C CONTROLLER

ASSEMBLY (A/C-ECU)

·COLUMN SWITCH

·FRONT DOME LIGHT

·KOS AND OSS-ECU

·LUGGAGE COMPARTMENT

LIGHT

·RADIO AND CD PLAYER

·ASC OFF SWITCH

·AUTO A/C CONTROLLER ASSEMBLY (A/C-ECU)

·COMBINATION METER

·CRUISE CONTROL SWITCH

·FRONT SIDE MARKER LIGHT (RH)

·HAZARD WARNING LIGHT SWITCH

·HEATED SEAT SWITCH

·HEATER CONTROL PANEL

·POSITION LIGHT (RH)

·RADIO AND CD PLAYER

·REAR COMBINATION LIGHT (TAILLIGHT:RH)

·SELECTOR LEVER ASSEMBLY

·STEERING WHEEL MULTI-FUNCTION SWITCH

JUNCTIONBLOCK

WIRE COLOR CODE

Trang 38

FUSIBLE LINKSBF3

RELAY BOX

STARTER RELAY

1 2

·CLUTCH INTERLOCK SWITCH

·TRANSMISSION RANGE SWITCH (P, N)

1

2

CONNECTOR (2)

NOTE : M/T 1 : CVT 2

Trang 40

RELAY BOX

SBF3

STARTER RELAY

CLUTCHINTERLOCKSWITCH(FOR STARTERRELAY)

JOINTCONNECTOR (2)

Định dạng
Số trang	248
Dung lượng	7,27 MB