We have synthesized ZnO nanoparticles by precipitation from zinc acetate ZnCH2C0 02.6H20 in different solvents: distilled water, absolute ethanol C2H5OH, and isopropanol C3H7OH.. h this
Trang 1V N U Jo u rn al o f S cience, M ath em a tics - P hysics 25 (2009) 71-76
Influence o f solvents on the growth o f zinc oxide
nanoparticles fabricated by microwave irradiation
Ta Dinh Canh*, Nguyen Viet Tuyen, Nguyen N goc Long
Faculty o f Physics, College o f Science, VNU, 334 Nguyen Trai, Thanh Xuan, Hanoi, Vietnam
Received 3 i July 2009; received in revised form 9 September 2009
Abstract A simple and rapid process has been developed for preparation of nanomcter-sừed ZnO powders via rnicrowave irradiation, by which ZnO powders wiứi an average particle size of 10-12
nm and narrow size disưibution can be synthesized in a short time We have synthesized ZnO nanoparticles by precipitation from zinc acetate (Zn(CH2C0 0)2.6H20) in different solvents: distilled water, absolute ethanol (C2H5OH), and isopropanol (C3H7OH) The ZnO nanopowders structure was characterized by X-ray powder diffraction (XRD) Raman scattermg studies confirm that the as-synthesized nanopowders are of high crystalline quality High-resolution transmission electron microscopy analysis reveals that the ZnO nanopowders have a perfect c.y^tallinity Photoluminescence have been observed Thus, microwave iưadiation can be an attractive method for industrial production of nanopowders
Keywords: ZnO, Nanopowder, Growth, Microwave technique, HRTEM, Optical property.
1 Introduction
h rcccnt years, great interests are focused on nanostructured zinc oxide (ZnO) because of its wide direct band gap, high exciton binding energy and promising applications for UV-lasers with low threshold [1], surficial acoustic devices [2], transistors and biosensors [3] in nanoscale The stable structure o f ZnO is wurtzite, in which four o f oxygen atoms in teừahedral coordination suưound each atoư o f zinc
Synthesis o f ZnO is often accomplished by sputtering, chemical vapor deposition and sol-gel techniques
h this paper, we report on the influence o f solvents on the synthesis o f ZnO nanoparticles from zinc acetate at temperature about 70°c The investigation o f the influence o f the solvents allows findng out a means to control over the ZnO nanoparticle size and size distribution, which is essential lor changing optical, electrical, and magnetic properties o f nanoparticles for specific applications Miciowave-solvolhermal synthesis has many advantages such as faster, simpler and more efficient than other methods [6,9]
Coresponding author Tel.: 0912272053
E-nail: canhtd@vnu.edu.vn
71
Trang 272 T.D Canh et al / VNU Journal o f Science, M athem atics - Physics 25 (2009) 71-76
2 Experimental
The ZnO nanoparticles were prepared by precipitation from solution using Zn(CH3C02)2 and NaOH The overall reaction for the synthesis o f ZnO nanoparticles from Zn(II) acetate can be wntten
as follows
Zn(CH3C02)2 + 2NaOH ^ ZnO + 2N a(CH3CƠ2) + H2O (1) The used solvents included distilled water, absolute ethanol (Merk 99%) and isopropanol (Merk 99%) The solvents were used as received without further purities
For typical preparation, 1 mmol o f zinc acetate dihydrate Zn(CH3C02)2-2H20 was dissolved in 80
ml o f solvent in covered flask under vigorous stirring at 50°c After cooling to room temperature, 8 ml
o f the fransparent zinc salt solution was added into 64 ml o f the pure solvent A 0.02 M NaOH solution was prepared by adding sodium hydroxide to the pure solvent in a covered flask under vigorous stirring at 60°c After cooling to room temperature, 8 ml o f the sodium hydroxide solution was added into 20 ml o f the pure solvent The sodium hydroxide solution was then added into the zinc acetate solution under vigorous stirring to give a total volume o f 100 ml with 0,1 mmol o f zinc acetate and 0,16 mmol o f NaOH From the overall reaction it follows that the synthesis is carried out with a 25% excess o f Zn(II) The resulting solution was then placed in a conventional microwave oven The microwave power was set to 150 w The reaction time was 5 minutes During the microwave iưadiation the temperature o f the solution reached up 70°c A fter 5 minutes, the transparent solution yields white products, which was washed several times w ith absolute ethanol and distilled water Finally the products were dried at 70°c for 4 hours
The morphologies and structures o f the products were investigated by SEM (JEOL-J8M5410 LV), TEM (JEOL JEM 1010, Japan), X-ray diffractometer (Bruker-AXSD5005) Raman scattering spectra
at room temperature in the energy region between 100 and 1000 cm ' were recorded by a micro-Raman spectrograph LABRAM -IB equipped with a He-Ne laser (X = 632,817 nm) with a power of 11 mW High-resolution fransmission electron microscopy (HRTEM ) images were obtained on a JEOL - 2010 TEM The photoluminescence (PL) measurement at room temperature was carried out on a 325 nm He-Cd laser A UV-vis specứophotometer (UV-2450PC Shimadzu) was used to record the UV-visible absorption spectra
3 Results and discussion
Fig 1 (a) X-ray dif&action patterns of ZnO nanoparticles prepared ừì different solvents: distilled water, absolute eứianol, and isopropanol, (b) Typical room- temperature micro-Raman spectrum of the sample
synthesized in isopropanol
Trang 3T.D Canh el al. / VNU Journal o f Science, M athem atics - Physics 25 (2009) 71-76 73
Figure 1(a) shows X-ray diffraction patterns o f ZnO nanoparticlcs prepared in different solvents
As indexed in the figure, all the diffraction peaks match those o f wurtzite ZnO with lattice constants of
a = 3.250 Ả and c = 5.207 A The strong diffraction peaks appear at 31.8, 34.3, and 36.5°, which correspond to (100), (002), and (101) planes o f wurtzite ZnO, respectively It should be pointed that in the XRD patterns except the diffraction peaks o f ZnO, no peak o f additional phase observed
The mean particle sizes have been estim ated using the Scherrer’s formula [5];
0.9Ẩ
(2)
PcosO where Ằ is the wavelength for the Kai com ponent o f the employed copper radiation (1.54056 A), p is Ihe corrected full width at half maximum (FW HM ) and G is the Bragg’s angle, and they average 59.6,
28.4 and 11.3 nm across, respectively, for the three samples prepared with distilled water, absolute ethanol and isopropanol These values agreed well with TEM observations (Fig 3) o f the ZnO nanopovvders
Fig 1 (b) shows a micro-Raman scattering spectrum o f the sample synthesized in isopropanol ZnO has a wurtzite crystal sfructure and belongs to C ô v group According to the group theory analysis, the
A1+E1+2E2 modes are Raman active The two higher peaks at 103 and 438 cm '' can be assigned to E2
modes, characteristic o f the wurtzite lattice The much weaker peak at 379 cm ' is attributed to the transverse optical modes o f A | The other two weaker and broader peaks at 203 and 333 cm ' can be assigned to the secondary Raman scattering arising from zero-boundary phonons 2-TA (M), and 2-E2
(M), respectively [10], The presence o f the E l ( L O , 580 cm ') mode o f oxygen deficiency indicates that there are oxygen vacancies in our ZnO nanoparticles The XRD and Raman specừa reveal good crystal quality
The EDS elemental analysis is shown in Fig.2 This result indicates that ZnO nanoparticles were only composed o f zinc (Zn) and oxygen (O) This suggested the high purity o f the ZnO nanopowders
Fig 2 Typical energy dispersion spectrum of ZnO nanopowders
The morphology and structure o f the ZnO powders were further investigated by TEM Figure 3 shovs TEM images with a low magnifier o f ZnO nanopaỉtid es prepared in different solvents It is clearly seen that, the ZnO nanoparticles prepared in different solvents have completely different sizes and shapes
Trang 474 T.D Canh et al. / VNU Journal o f Science M athematics - Physics 25 (2009) 71-76
Fig 3 TEM images ofZnO nanoparticles prepared in different solvents:
a) distilled water; b) absolute eứianol; and c) isopropanol
When we use distilled water as a solvent, ZnO nanoparticles has ellipse shape and large size with size o f larger axis is about 100 nm and size o f the other axis is about 40 nm In addition, the size distribution is not very narrow With ethanol as solvent, the obtained nanostructure has rod form with length is about 45 nm and radius is about 20 nm However, when isopropanol is used as a medium to create nanoparticles, we obtain spherical particles with radius o f 10-12 nm Furthermore, nanoparticles prepared in isopropanol have more homogenous size and shape
TEM gives us more details about microsfructure o f the ZnO nanopowders prepared in isopropanol,
as shown in Fig 4 The nanopowders are of good ừansparency for the electron beam The particlcs appeared to be well separated from each other Fig 4a shows the morphologies o f ZnO nanoparticlcs containing mainly spherical particles typically with diameters ranging from 10 to 15 nm Fig 4b shows the selected area elecfron diffraction (SAED) pattern o f the produced nanopowder The SAED pattern shows ring pattern without any additional spots and rings o f secondary phases revealing their highly crystalline ZnO wurtzite structure Three fringe patterns were observed with plane distances of
o f pure wurtzite hexagonal structure o f ZnO The fringe spacing is about 0.28 nm, corresponding to the (100) crystal planes o f ZnO (Fig 4c) The SAED o f a single ZnO nanoparticle reveals that the ZnO product exhibits a single-crystal structure, which is in good agreement with the XRD data
Fig 4 (a) Magnified TEM image of ZnO nanopowder prepared in isopiopanol, (b) corresponding electron diffraction pattern, and (c) HR-TEM image of siflgio ZnO nanopaniole showed (100) crystalline planes
Trang 5T.D Canh e t aỉ / VNU Journal o f Science M athem atics - Physics 25 (2009) 71-76 75
Coarsening involves the growth o f larger crystals at the expense o f smaller crystals and is governed by capillary effects Since the chemical potential o f a particle increases with decreasing particle size, the equilibrium solute concentration for a small particle is much higher than that for a large particle The resulting concentration gradients lead to transport o f solute (e.g., metal ions) from the small particles to the larger particles The rate law for this process, derived by Lifshitz, Slyozov, and Wagner (LSW) [4], is given by
(3)
is the average initial radius, k is the rate constant, and / is where r is the average particle radius,
time The rate constant k is given by [4]
(4)
is the equilibrium concentration at a flat
54;rr/aN^
where y is the surface energy, is the molar volume,
surfacc (i.e., the bulk solubility), T] is the viscosity o f the solvent (in room temperature, T]^ter = 8.9-^^I0'^Pa.s,J]absoiuteihanoi = 10.74 ^ 10'^ Pa.s and rii,„ p r o p a n o l ='^9 AS ^\ữ^Pa.s[A]) and a is the solvated
ion radius
From equation (4) it is apparent that the rate constant k - if and y are independent o f the solvent It’s clearly seen that our experiment results agree well with LSW model
Photoluminescence and absorption spectra o f the ZnO nanoparticles prepared in isopropanol are showTi in Fig 5 A broad emission band centered at 528 nm was observed This green emission band is attributed to the radiative recombination o f photogenerated holes with electrons belonging to singly ionized oxygen vacancies in the surface and subsurface [9] The observation o f the green band emission stronger than that in the bulk ZnO indicates the existence o f oxygen vacancies concentrated
on nanoparticle surface
The absorption spectrum o f ZnO nanoparticles dispersed in ethanol solution is shown in the inset of lMg.5 The optical band gap o f ZnO nanoparticles was calculated from the measured absorption data of samples Fig 6 shows a plot o f the square o f the absorption coefficient a o f ZnO nanoparticles versus photon energy From the figure, the band gap value is found to be o f 3.40 eV Compared with bulk ZnO (Hg = 3.37 eV), the blue shift observed in the ZnO nanostructures is due to the quantum size effect
Wavelength (nm)
Fig 5 The PL spectrum of the ZnO nanopowders
'The inset shows UV-vis spectrum of the ZnO
nanopowders
Energy (eV)
Fig 6 Square of the absorption coefficient as a
function 0i photon energy
Trang 676 T.D Canh et al / VNU Journal o f Science, M athematics - Physics 25 (2009) 71-76
I he average panicle size m colloid can be oDlained from ihe absorpiion onscl using liic ciieciivc mass model [4,7] where the the band gap £’g(in eV) can be approximated by:
(5)
2 er { m l m j ATTse^r h ^ 4 ;re£^) 1,/« ; n ĩ , )
where is the bulk band gap (eV), h is Plank’s constant, r is the particle radius, We* is electron effective mass, nth is hole effective mass, nto is free elecừon mass, e is the charge on the electron, f: is
the relative permittivity, and So is the permittivity o f free space Due to the small effetive masses from
ZnO (nỉe = 0.26 Wo, = 0,59 //io €= 8,5 [4,8]), band gap enlargement give us the expccted particle
size o f about 9 nm
4 Conclusion
The ZnO nanoparticles were prepared using microwave iưadiation which is an easy and very fast method XRD results showed that the obtained ZnO nanoparticles were composed o f hexagonal wurtzite phase with very good crystallinity For different solvents, the kinetics o f coarsening was consistent with the Lifshitz-Slyozov-Wagner model For the ZnO nanopaticles prepared in isopropanol, the size o f 11.3
nm obtained by using Scherer formula was in good agreement with TEM results
Acknowledgments This work is completed with financial support by the Vietnam National
University, Hanoi (Key Project QG 09 05 and Key Project TN 09 09) Authors o f this paper would like
to thank the Center for Materials Science (CMS), Faculty o f Physics, Hanoi University o f Science, VNU for permission to use its equipments
References
[1] M.R Vaezi, S.K Sadmezhaad, Nanopowder synthesis o f zinc oxide via solochcmical processing Materials and Design
28(2007)515.
[2] Y.J Kwon, K.H Kim, c s Lim, K.B Shim, Characteri/ation o f ZnO nanopowders synthesized by the polymcri/.cd
complex method via an organochemical route, Journal o f ceramic processing research 3 (2002) ! 46.
[3] J.G Lu, z z Ye J.Y Huang, L.p Zhu, B.H Zhao, Z.L Wang, Sz Fujita, ZnO quantum dots synthesized by a vapor
phase transport proccss, Applied physics letters 88 (2006) 1.
[4] z Hu, G Oskam, p c Searson, Influence of solvent Oil ứìc gro /th o f ZnO nanoparticles Journal o f Coỉỉoidand Interface Science 263 (2003) 454.
[5] B.D Cullily, Elements o f X-ray diffractions (Ediiion-WesUy,ReuJmg Af A) (1978) 102.
[6] G Glaspell, p Dutta, A Manivannan, A rooni-temperature ajid I Jcrowave synthesis o f M-dopcd ZnO (M = Co, Cr.
Fe, Mn & Ni), Journal o f cluster science 16 (2005), 523.
[7] A.D Yoffe, Low-dimensional systen\s: quantum size effects and electronic properties o f semiconductor
microcrystallites (Zero-dimensional Systems) and some quasi-two-dimensional systems, Advances in Physics 5Ị (2002)
799.
[8] S Shionoya, W.M Yen (Eds), Phosphor Handbook CRC, Boca Raton, FL 1998.
[9] N.F Hamedani, F Farzaneh, Synthesis o f nanocrystals with hexagonal (wurtzite) structure in water using microwave
iiradiaiion, Journal o f Science Islamic republic o f Iran 17 (2006) 231.
[10] N v Tuyen, T.D Canh, N.N Long, T.T.Q Hoa, N x Nghia, Đ.II Chi, K Higashimine, T Mitani, Indium doped Zinc
oxide naomenter thick disks synthesized by a vapor phase transport proccss, Journal o f Experimental Nanoscience
2008 (in the press).